Leftover farm pads need Concrete Removal in Hebron first

We’ve had leftover pads sitting right where a new shop slab needed to go. You can’t pour over that. On Hebron farm lots we still run into the old pad from a machine shed that came down years ago, or a rectangle of concrete that used to hold a feed bin. It looks like a head start, and it still has to come out. The grade is wrong and the thickness is whoever poured it last. The new work has to sit on a base we trust.

A lot of those pads were poured for something that isn’t there anymore. Barns get taken down. Equipment gets parked somewhere else. The concrete stays because it’s heavy and nobody wanted to deal with it that season. We’ve had people want a new floor for a shop or a clean pad for a trailer, and that leftover slab was in the way. That’s when Concrete Removal in Hebron has to happen before a new pour.

Concrete Removal in Hebron starts with the leftover pad

We break it, we load it, we haul it, and we leave the dirt where we can actually work. Until that pad is gone, we don’t have a clean shot at the subgrade. On rural Hebron properties the old concrete is often thicker at one end than the other. We’ve cut into pads that were thin on the edge and a lot thicker where someone piled extra mix. Wire mesh shows up. So does rebar that doesn’t match any pattern. Sometimes there’s a layer of dirt and gravel packed against the side of it that has to come out with the slab so the new pour can sit level.

If we poured over it, the new slab would pick up every hump and every low corner underneath. We’ve seen oil-soaked spots on old equipment pads too. That surface doesn’t bond well and it doesn’t belong under a finished floor. We’ve been family owned and operated since our doors opened back in 2006, and we still do this the same way. Get the old concrete off the lot, then build the new work. Our goal is to get in and out as quickly as possible leaving a professional and quality job.

What we hit on farm lots during Concrete Removal in Hebron

Day to day this is breaker work and loading. A farm pad sits in a different kind of yard than a driveway. Some of them have a little curb someone formed with a 2×4. Others stop short of a fence and leave a buried lip we only find once we start. We’re careful around well heads, propane tanks, buried cable, and old post footings that got poured into the same slab. Chunks come out with dirt stuck to them. Mesh springs up when the slab lets go. That’s the part people don’t picture when they look at a rectangle of gray sitting in the grass.

Hauling is the other half. Broken concrete is heavy, and a farm lot in Hebron often means a long driveway and a place we have to stage the truck without chewing up a yard or a planted field. Grass grows over the edges of these pads, so the slab is usually bigger than it looks from the house. We load what we break and take it with us. People looking for our concrete removal work on these lots are usually trying to clear space for a pour.

New grade after Concrete Removal in Hebron

Once the pad is gone we can see the dirt under it. On Hebron farm lots the ground under an old pad is often packed hard in the middle and soft at the edges. We look at that and we bring it to grade. Then we pour. Concrete Removal in Hebron is what makes that sequence possible. We source our products so that we know that they are the best available when the new slab goes in, and we write the quote out line by line for the breakout and the haul so the numbers sit in front of everyone the same way. The new pour gets its own line.

We’ve been doing this around North West Indiana and the Tri-State area. On a farm lot the leftover pad is the first thing we deal with. In Hebron that usually means walking the slab and marking what has to come out, then figuring where the truck can sit so we don’t tear up more ground than we have to.