Gary Indiana Concrete Garage Floors for Older Lots

Concrete Garage Floors in Gary pit by spring when an unheated detached garage holds meltwater and road salt through the freeze. The water works into the top of the slab. The next hard freeze breaks the paste off in shallow pits.

On older lots the detached garage often sits at the back of the property. We have worked on places in Gary where that garage faces the alley. Because the building has no heat, the floor stays cold long after the driveway gets sun. So slush off the tires stays on the slab with the road salt.

People call us in April when the floor looks chewed up and they can’t sweep it clean. We have pulled up slabs with pits across the parking lanes after a winter of salt and melt. The damage shows up where the tires sit, and also along the door where meltwater pools. After repeated winters the pits join up and the surface turns to dust under a broom.

An unheated detached garage keeps that wet film in place. When the door closes, the cold stays in, and the salt water freezes again overnight. For example, a car parked after a lake-effect snow can drip for hours onto a slab that is already cold.

Road salt rides in on the mats and the undercarriage too. We have swept garages in Gary where a white crust sat in the tire lanes into spring. But the scaling starts under that crust, in the paste, before anyone sweeps.

Winter Planning for Concrete Garage Floors in Gary

We plan the pour around winter, because that’s when the slab takes meltwater and road salt. On older lots in Gary an unheated detached garage collects both. The tires bring in slush from the street. A low spot inside the door holds it until the next freeze.

We have seen old slabs pitched back toward the rear wall, so alley water and roof drip both stay inside. When that happens the salt water soaks the concrete. A new floor has to send that water out the door. After we set the grade, the middle of the slab sits a little higher than the threshold.

Concrete Garage Floors in Gary Start With the Base

When the pits run deep, patch work won’t stay put. We handle concrete removal and a new pour. Concrete Garage Floors in Gary on an older lot start with a compacted stone base. Then we pour a slab sloped to the door, so winter melt leaves the building.

We saw-cut or break out the old concrete, haul it off, and check the soil under it. We have found thin pours over soft ground in older Gary garages. Because that ground holds water, we put stone down and compact it before the truck arrives. We place air-entrained concrete, since this slab will freeze while it’s wet with salt.

Concrete Garage Floors in Gary pick up salt at the joint where the slab meets the apron. We have replaced that joint in the same visit when the outside pad was breaking up. So the quote lists the concrete and the hours as their own lines.

Look through our concrete garage floors work for the floors we pour. Finished bays are in our photo gallery. When the old floor is only rough in one lane, we can trench-cut that strip and pour it back. A floor that pits across the whole parking area needs a full replacement.

We are a family owned and operated company, and our doors opened in 2006. Cabe’s has poured Concrete Garage Floors in Gary on older detached garages. The same crew covers the towns in our northwest Indiana service area.

A detached garage on an older Gary lot also picks up salt at the apron and along the alley edge. When those pieces are failing, we can replace the apron with the floor so the new joint starts clean. Control joints go in while we can still tool the concrete.